Effects of Different Color Protection and Drying Methods Treatment on the Quality of Asparagus Powder

ZHAO Shishan; SHI Jianbin; SUI Yong; CAI Sha; XIONG Tian; LI Shaobin; CAI Fang; MEI Xin

doi:10.13386/j.issn1002-0306.2022060091

Volume 44 Issue 11

May 2023

Turn off MathJax

Article Contents

Abstract

References

Science and Technology of Food Industry > 2023 > 44(11): 54-64. > DOI: 10.13386/j.issn1002-0306.2022060091

ZHAO Shishan, SHI Jianbin, SUI Yong, et al. Effects of Different Color Protection and Drying Methods Treatment on the Quality of Asparagus Powder[J]. Science and Technology of Food Industry, 2023, 44(11): 54−64. (in Chinese with English abstract). doi: 10.13386/j.issn1002-0306.2022060091.

Citation:

PDF (6965 KB)

Effects of Different Color Protection and Drying Methods Treatment on the Quality of Asparagus Powder

1.
Institute of Agricultural Products Processing and Nuclear Agricultural Technology, Hubei Academy of Agricultural Sciences, Wuhan 430064, China
2.
School of Life Sciences, Yangtze University, Jingzhou 434025, China

More Information

Received Date: June 09, 2022
Available Online: April 05, 2023

Graphical Abstract

Abstract

Abstract

Different color protection agents were used to soak and spray the asparagus for color protection due to improve and compare the browning problem of asparagus during the process of hot air, vacuum freezing and microwave drying. The results showed that the quality of nutrition and color of asparagus powder with color protection was better than that without color protection. The color protection effect of Hu3 was significantly better than that of Hu2 and Hu1 (P<0.05). The synergistic use of drying method and color fixative was better than that of single drying. Among them, the retention degree of phenols, structural integrity, color and antioxidant capacity of asparagus powder treated by color fixative and vacuum freeze drying (VFD) were the best. The structure of asparagus powder treated by color fixative and hot air drying (HAD) was sparse and dispersed, and the content of phenols, color and antioxidant capacity were lower than VFD. However, the asparagus powder obtained by color fixative and microwave drying (MD), was bright yellow, with the worst nutrition and color quality. In addition, compared with soaking, the water soluble dietary fiber (SDF) content of sprayed asparagus powder was higher, and the adsorption capacity of glucose and cholesterol was better, but the color protection effect of the former was better. The results of principal component analysis showed that the total phenol, rutin, physicochemical and functional properties of asparagus powder were highly correlated with its nutrition and color quality. The top three asparagus powder in terms of comprehensive quality were Hu3-Soak-VFD, Hu2-Soak-VFD and Hu3-Spray-VFD. The last three were Hu1-Spray-MD, Hu2-Spray-MD and control-MD. The results of this study provide a theoretical basis for improving the quality of dried asparagus products.
- asparagus powder,
- color protection method,
- drying method,
- polyphenols,
- physical and chemical properties,
- functional characteristics,
- color quality

FullText(HTML)

References (34)

References

[1]	魏云潇, 王楠, 余作龙, 等. 采后芦笋多酚类物质变化的研究进展[J]. 保鲜与加工,2022,22(1):102−109. [WEI Yunxiao, WANG Nan, YU Zuolong, et al. Research progress on changes of polyphenols in postharvest asparagus[J]. Storage and Process,2022,22(1):102−109. doi: 10.3969/j.issn.1009-6221.2022.01.014
[2]	MEKA K W, DUKASSA D A, TOFIK A E. Nephroprotective effect of Asparagus africanus Lam. root extract against gentamicin-induced nephrotoxicity in swiss albino mice[J]. Journal of Toxicology,2022,22(19):2−5.
[3]	BHALODIYA M, CHAVDA J, PATEL N. Evaluation of solvent extraction process for Asparagus racemosus root extract through the determination of its phenolic content and antioxidant activity assay[J]. Research Journal of Pharmacy and Technology,2021,14(10):5108−5114.
[4]	周驰. 芦笋粉加工关键技术及应用研究[D]. 泰安: 山东农业大学, 2015. ZHOU Chi. Research on key technology and application of asparagus powder processing [D]. Taian: Shandong Agricultural University, 2015.
[5]	杨强. 芦笋中多酚氧化酶(PPO)酶学特性研究[J]. 科技创新与应用,2013(23):1−7. [YANG Qiang. Study on enzymatic characteristics of polyphenol oxidase (PPO) in asparagus[J]. Technology Innovation and Application,2013(23):1−7.
[6]	赵洪军, 朱丹, 王珂, 等. 芦笋提取液体外抗氧化、细胞毒作用及抑制α-葡萄糖苷酶活性研究[J]. 天然产物研究与开发,2011,23(2):356−360. [ZHAO Hongjun, ZHU Dan, WANG Ke, et al. Antioxidant, cytotoxic and inhibitory effects of asparagus extract in vitro α-study on glucosidase activity[J]. Natural Product Research and Development,2011,23(2):356−360. doi: 10.3969/j.issn.1001-6880.2011.02.037
[7]	付三乔. 芦笋无硫护色工艺的研究[J]. 湖北农业科学,2011,50(6):1247−1249. [FU Sanqiao. Study on sulfur free color protection technology of asparagus[J]. Hubei Agricultural Sciences,2011,50(6):1247−1249. doi: 10.3969/j.issn.0439-8114.2011.06.049
[8]	朱蕴兰, 陈宏伟, 陈安徽, 等. 不同干燥方式对芦笋营养与品质特性的影响[J]. 北方园艺,2018(1):129−134. [ZHU Yunlan, CHEN Hongwei, CHEN Anhui, et al. Effects of different drying methods on nutrition and quality characteristics of asparagus[J]. Northern Horticulture,2018(1):129−134. doi: 10.11937/bfyy.20171059
[9]	杜俊娜, 陈书霞, 程智慧, 等. 响应曲面法优化大蒜中总酚提取工艺及其抗氧化活性的测定[J]. 食品科学,2012,33(10):6−9. [DU Junna, CHEN Shuxia, CHENG Zhihui, et al. Optimization of extraction process of total phenols from garlic and determination of antioxidant activity by response surface methodology[J]. Food Science,2012,33(10):6−9.
[10]	杨永涛. 罗布麻总黄酮的提取、分离纯化及其抗氧化性能研究[D]. 广州: 华南理工大学, 2018. YANG Yongtao. Study on extraction, purification and antioxidant properties of total flavonoids from Apocynum venetum[D]. Guangzhou: South China University of Technology, 2018.
[11]	殷丛培, 吴盟, 王志博, 等. 高粱籽粒中9种黄酮类化合物的积累特性分析[J]. 中国粮油学报,2022,37(12):76−83. [YIN Congpei, WU Meng, WANG Zhibo, et al. Accumulation characteristics of 9 flavonoids in sorghum grains[J]. Journal of the Chinese Cereals and Oils Association,2022,37(12):76−83. doi: 10.3969/j.issn.1003-0174.2022.12.012
[12]	陈洁, 张智勇, 李璞, 等. 马铃薯生全粉-小麦粉混粉面团特性研究[J]. 河南工业大学学报(自然科学版),2021,42(01):1−7. [CHEN Jie, ZHANG Zhiyong, LI Pu, et al. Study on characteristics of potato raw whole flour wheat flour mixed dough[J]. Journal of Henan University of Technology(Natural Science Edition),2021,42(01):1−7.
[13]	蔡沙, 隋勇, 施建斌, 等. 马铃薯膳食纤维物化特性分析及其对马铃薯热干面品质的影响[J]. 食品科学,2019,40(4):87−94. [CAI Sha, SUI Yong, SHI Jianbin, et al. Analysis of physicochemical characteristics of potato dietary fiber and its effect on the quality of potato hot and dry noodles[J]. Food Science,2019,40(4):87−94. doi: 10.7506/spkx1002-6630-20171213-151
[14]	张毅, TAWANDA Muzhingi, 岳瑞雪, 等. 东非不同肉色甘薯的营养品质分析与综合评价[J]. 江苏师范大学学报:自然科学版,2020,38(2):6−7. [ZHANG Yi, TAWANDA Muzhingi, QIU Ruixue, et al. Nutritional quality analysis and comprehensive evaluation of sweet potatoes with different meat colors in East Africa[J]. Journal of Jiangsu Normal University:Natural Science Edition,2020,38(2):6−7.
[15]	陈蓬凤, 梅新, 黄师荣, 等. 不同品种薯尖的总酚、总黄酮含量及抗氧化活性比较[J]. 现代食品科技,2021,37(3):132−138. [CHEN Pengfeng, MEI Xin, HUANG Shirong, et al. Comparison of total phenols, total flavonoids and antioxidant activity of potato tips of different varieties[J]. Modern Food Science and Technology,2021,37(3):132−138.
[16]	TI Huihui, LI Qing, ZHANG Ruifen, et al. Free and bound phenolic profiles and antioxidant activity of milled fractions of different indica rice varieties cultivated in Southern China[J]. Food Chemistry,2014,159:166−174. doi: 10.1016/j.foodchem.2014.03.029
[17]	ZHANG Liuquan, LI Yi, LIANG Ying, et al. Determination of phenolic acid profiles by HPLC-MS in vegetables commonly consumed in China[J]. Food Chemistry,2018,276(13):12−17.
[18]	付龙威, 连建梅, 叶淑贤, 等. 不同干燥工艺对燕窝品质特性的影响[J]. 食品工业科技,2022,5(13):1−12. [FU Longwei, LIAN Jianmei, YE Shuxian, et al. Effects of different drying processes on the quality characteristics of bird's nest[J]. Science and Technology of Food Industry,2022,5(13):1−12. doi: 10.13386/j.issn1002-0306.2021110300
[19]	王润丰. 四种百合黄酮类化合物分离纯化与抗氧化作用的研究[D]. 咸阳: 西北农林科技大学, 2011. WANG Runfeng. Isolation and purification of four flavonoids from lily[D]. Xianyang: Northwest University of Agriculture and Forestry Science and Technology, 2011.
[20]	姚红娟. 芦笋茎秆中膳食纤维素及微晶纤维素提取工艺的研究[D]. 济南: 齐鲁工业大学, 2017. YAO Hongjuan. Study on extraction technology of dietary cellulose and microcrystalline cellulose from asparagus stems[D]. Jinan: Qilu University of Technology, 2017.
[21]	PETITOT M, ABECASSIS J, MICARD V. Structuring of pasta components during processing: Impact on starch and protein digestibility and allergenicity[J]. Trends in Food Science & Technology,2009,20(11-12):521−532.
[22]	扶庆权, 王海鸥, 陈雨, 等. 不同干燥方式对白玉菇品质的影响[J]. 食品研究与开发,2019,40(17):5−8. [FU Qingquan, WANG Haiou, CHEN Yu, et al. Effect of different drying methods on the quality of white jade mushroom[J]. Food Research and Development,2019,40(17):5−8. doi: 10.12161/j.issn.1005-6521.2019.17.026
[23]	YAN Weiqiang, ZHANG Ming, HUANG Luelue, et al. Influence of microwave drying method on the characteristics of the sweet potato dices[J]. Journal of Food Processing & Preservation,2013,37(5):662−669.
[24]	WANG Liling, QIN Yuchuan, WANG Yanbin, et al. A pair of homoisoflavonoid analogues (6-aldehydo-isoophiopogonanone A/6-aldehydo-isoophiopogonanone B) from Ophiopogon japonicus as a tyrosinase inhibitor: Inhibitory activity, conformational change and mechanism[J]. European Food Research and Technology,2021(prepublish):123−126.
[25]	黄建立, 黄艳, 郑宝东, 等. 不同干燥方式对银耳品质的影响[J]. 中国食品学报,2010,10(2):167−173. [HUANG Jianli, HUANG Yan, ZHENG Baodong, et al. Effects of different drying methods on the quality of Tremella[J]. Journal of Chinese Institute of Food Science and Technology,2010,10(2):167−173. doi: 10.3969/j.issn.1009-7848.2010.02.025
[26]	刘静娜, 黄志娜, 吴丽萍. 芦笋膳食纤维的提取及其在面包中的应用[J]. 食品科技,2010,35(11):178−185. [LIU Jingna, HUANG Zhina, WU Liping. Extraction of asparagus dietary fiber and its application in bread[J]. Food Science and Technology,2010,35(11):178−185. doi: 10.13684/j.cnki.spkj.2010.11.035
[27]	黄萍, 林亲录, 朱凤霞, 等. 米糠水溶性膳食纤维理化特性及抗氧化性[J]. 食品科学,2017,38(23):14−19. [HUANG Ping, LIN Qinlu, ZHU Fengxia, et al. Physicochemical properties and antioxidant properties of rice bran water-soluble dietary fiber[J]. Food Science,2017,38(23):14−19. doi: 10.7506/spkx1002-6630-201723003
[28]	王艳丽, 刘凌, 孙慧, 等. 膳食纤维的微观结构及功能特性研究[J]. 中国食品添加剂,2014(2):98−103. [WANG Yanli, LIU Ling, SUN Hui, et al. Study on microstructure and functional properties of dietary fiber[J]. China Food Additives,2014(2):98−103. doi: 10.3969/j.issn.1006-2513.2014.02.011
[29]	桂青, 王秀全, 黄坚雄, 等. 不同干燥方式对五指毛桃品质的影响[J]. 食品工业科技,2019(4):1−14. [GUI Qing, WANG Xiuquan, HUANG Jianxiong, et al. Effects of different drying methods on the quality of five fingered peach[J]. Science and Technology of Food Industry,2019(4):1−14.
[30]	刘颖. 大气液相中典型酚类污染物与超氧阴离子自由基的光化学反应[D]. 合肥: 合肥工业大学, 2021. LIU Ying. Photochemical reaction of typical phenolic pollutants with superoxide anion radical in atmospheric liquid phase[D]. Hefei: Hefei University of Technology, 2021.
[31]	贾毅伟, 张家荣, 陈果, 等. 芦笋老茎中总黄酮的提取及其抗氧化性能[J]. 南昌大学学报(工科版),2020,42(2):144−193. [JIA Yiwei, ZHANG Jiarong, CHEN Guo, et al. Extraction and antioxidant activity of total flavonoids from old asparagus stems[J]. Journal of Nanchang University(Engineering & Technology),2020,42(2):144−193.
[32]	王盛林, 赵震宇, 刘平怀, 等. 胶网藻1A10营养成分及羟基自由基清除能力研究[J]. 上海海洋大学学报,2018,27(2):196−205. [WANG Shenglin, ZHAO Zhenyu, LIU Pinghuai, et al. Study on nutritional components and hydroxyl radical scavenging ability of jiaoreticulina 1A10[J]. Journal of Shanghai Ocean University,2018,27(2):196−205.
[33]	龙晓珊, 廖森泰, 刘书成, 等. 肉桂多酚清除自由基及抑制α-葡萄糖苷酶活性的能力[J]. 现代食品科技,2021,37(8):119−126. [LONG Xiaoshan, LIAO Sentai, LIU Shucheng, et al. Free radical scavenging and inhibition of cinnamon polyphenols α-ability of glucosidase activity[J]. Modern Food Science and Technology,2021,37(8):119−126.
[34]	杨晓宽, 李汉臣, 张建才, 等. 芦笋膳食纤维品质分析及抗氧化性研究[J]. 中国食品学报,2013,13(10):205−212. [YANG Xiaokuan, Li Hanchen, ZHANG Jiancai, et al. Quality analysis and antioxidant activity of asparagus dietary fiber[J]. Journal of Chinese Institute of Food Science and Technology,2013,13(10):205−212. doi: 10.16429/j.1009-7848.2013.10.009

[1]	YUAN Xin, ZHU Huijuan, MA Lingjun, CHEN Fang, LIAO Xiaojun, HU Xiaosong, JI Junfu. Effects of Superfine Grinding and High-pressure Processing on Physicochemical Properties and Polyphenol Antioxidant Activity of Barley Leaves[J]. Science and Technology of Food Industry, 2025, 46(7): 78-86. DOI: 10.13386/j.issn1002-0306.2024040188
[2]	JIANG Lina, ZHANG Xiuqing, PEI Haisheng, LI Yuanyuan, LIANG Liang, HU Xuefang, ZHANG Zhimin, ZHAI Xiaona. Effect of Superfine Grinding Technology on the Quality Characteristics of Zanthoxylum bungeanum Seed Powder[J]. Science and Technology of Food Industry, 2024, 45(8): 67-74. DOI: 10.13386/j.issn1002-0306.2023040017
[3]	ZHAO Yuhan, QIN Chang, SUN Fei, HAN Cong, CHEN Qingmin, YUE Fengli, CUI Bo, DU Yamin, FU Maorun, LI Fangrui. Effects of Superfine Grinding Treatment on the Physicochemical and Functional Properties of Mixed Congee Powder[J]. Science and Technology of Food Industry, 2022, 43(18): 21-28. DOI: 10.13386/j.issn1002-0306.2021090335
[4]	REN Xiaochan, CHANG Jingyao, MA Xiaoli, KONG Baohua, XIN Ying, HU Gongshe, LIU Qian. Effects of Different Particle Sizes on the Quality of Barley Flour after Superfine Grinding[J]. Science and Technology of Food Industry, 2022, 43(10): 80-86. DOI: 10.13386/j.issn1002-0306.2021080063
[5]	SHI Zao, ZHANG Fusheng, YANG Jinlai, WU Liangru, ZHENG Jiong. Effect of Superfine Grinding on Physicochemical Properties and Microstructure of Chimonobambusa quadrangularis Shoot Powder[J]. Science and Technology of Food Industry, 2021, 42(24): 40-47. DOI: 10.13386/j.issn1002-0306.2021040079
[6]	CHEN Jie, TAN Lin, ZHANG Qing, ZHANG Li-hua. Research Progress of Superfine Grinding Technology in Tofu Processing[J]. Science and Technology of Food Industry, 2018, 39(20): 324-329. DOI: 10.13386/j.issn1002-0306.2018.20.055
[7]	XIA Wen, HU Yang, LI Ji-hua, WEI Xiao-yi, WANG Fei, LIN Yan-yun. Effects of superfine grinding on retrogradation properties of tapioca starch[J]. Science and Technology of Food Industry, 2017, (24): 44-47. DOI: 10.13386/j.issn1002-0306.2017.24.009
[8]	WANG Ping, CHEN Qin-qin, BI Jin-feng, LIU Xuan, YI Jian-yong, ZHOU Lin-yan, ZHONG Yao-guang. Influence of superfine grinding on quality characteristic of jackfruit powder[J]. Science and Technology of Food Industry, 2015, (01): 144-148. DOI: 10.13386/j.issn1002-0306.2015.01.022
[9]	CHEN Jun, LIANG Rui-hong, LIU Xin-yu, LIU Wei, WU Shuang-shuang. Effect of superfine grinding of Lotus nut on the release rates of active ingredients[J]. Science and Technology of Food Industry, 2014, (23): 123-126. DOI: 10.13386/j.issn1002-0306.2014.23.016
[10]	Effect of superfine pulverizing on properties of millet bran dietary fiber[J]. Science and Technology of Food Industry, 2013, (13): 128-131. DOI: 10.13386/j.issn1002-0306.2013.13.044