Effects of Salting Conditions on the Morphology and Composition of Cooked Salted Duck Eggs Yolk

XU Qunbo; LI Xiuhua; XIAO Xinglong; YU Yigang

doi:10.13386/j.issn1002-0306.2022060301

Volume 44 Issue 11

May 2023

Turn off MathJax

Article Contents

Abstract

References

Science and Technology of Food Industry > 2023 > 44(11): 80-87. > DOI: 10.13386/j.issn1002-0306.2022060301

XU Qunbo, LI Xiuhua, XIAO Xinglong, et al. Effects of Salting Conditions on the Morphology and Composition of Cooked Salted Duck Eggs Yolk[J]. Science and Technology of Food Industry, 2023, 44(11): 80−87. (in Chinese with English abstract). doi: 10.13386/j.issn1002-0306.2022060301.

Citation:

PDF (11417 KB)

Effects of Salting Conditions on the Morphology and Composition of Cooked Salted Duck Eggs Yolk

1.
School of Food Sciences and Technology, South China University of Technology, Guangzhou 510640, China
2.
School of Chemistry and Chemical Engineering, South China University of Technology, Guangzhou 510640, China

More Information

Received Date: June 28, 2022
Available Online: April 04, 2023

Graphical Abstract

Abstract

Abstract

In order to explore the effects of salting conditions on the morphology and composition of cooked salted duck egg yolk (SDEY), and reduce the content of hard core in the cooked SDEY, the physicochemical properties of different parts of salted egg yolk and the microstructure of raw and cooked salted egg yolk were analyzed through weighing, atomic flame absorption spectrometry, Kjeldahl method, differential scanning calorimetry (DSC), Fourier transform infrared spectroscopy (FTIR) and scanning electron microscope (SEM). The results revealed an appearance of the hard core of SDEY in the second week of the pickling process, which gradually increased with time. Specifically, the yolk hard core of the well-pickled salted duck egg accounted for 33.64%~44.80% of the total mass of the yolk and 21.47%~23.49% of the moisture content. The Na⁺ content of the hard core was 10.66~11.47 mg/g. Notably, the hard core of SDEY had lower free fat content, which was about 17.71%~27.90% compared with 34.79%~36.34% of the outer layer, while the free fat content of the hard core was positively correlated with the salt concentration of the pickling liquid. In addition, the protein content of the hard core of egg yolk increased to more than 30% after salted, which was higher than the outside. Moreover, it was found that the particle size of the yolk particles in the hard core was smaller after heating, which presented a continuous structure with smaller gaps. Thus, from the results, the order of salt penetration led to the differences in the structure and composition of different parts of salted egg yolk, which led to the differences in the hard core and the outside of the yolk after heating. Higher pickling time and salt concentration significantly aggravated the formation of the hard core. Therefore, using a concentration of 15% and pickling time for 4 week could make less hard core and better food quality. Hence, this study provides a guide to improving the quality of SDEY.
- salted egg yolk,
- hard core,
- protein,
- microstructure

FullText(HTML)

References (37)

References

[1]	张晓维, 郑萍, 高洁, 等. 3种方法腌制咸蛋理化性质的对比[J]. 食品研究与开发,2020,41(12):108−116. [ZHANG Xiaowei, ZHENG Ping, GAO Jie, et al. Comparison of physicochemical properties of salted eggs by three pickling methods[J]. Food Research and Development,2020,41(12):108−116. doi: 10.12161/j.issn.1005-6521.2020.12.018
[2]	DENMAT M L, ANTON M, GANDEMER G. Protein denaturation and emulsifying properties of plasma and granules of egg yolk as related to heat treatment[J]. Journal of Food Science,1999,64(2):194−197. doi: 10.1111/j.1365-2621.1999.tb15863.x
[3]	KAEWMANEE T, BENJAKUL S, VISESSANGUAN W. Changes in chemical composition, physical properties and microstructure of duck egg as influenced by salting[J]. Food Chemistry,2009,112(3):560−569. doi: 10.1016/j.foodchem.2008.06.011
[4]	吕蕙, 马美湖, 刘远远. 稻秸灰水提物对咸蛋黄理化特性的影响[J]. 现代食品科技,2019,35(4):148−156. [LÜ Hui, MA Meihu, LIU Yuanyuan. Effects of straw ash aqueous extracts on physicochemical characteristics of salted egg yolk[J]. Modern Food Science and Technology,2019,35(4):148−156.
[5]	KAEWMANEE T, BENJAKUL S, VISESSANGUAN W, et al. Effect of sodium chloride and osmotic dehydration on viscoelastic properties and thermal-induced transitions of duck egg yolk[J]. Food and Bioprocess Technology,2013,6(2):367−376. doi: 10.1007/s11947-011-0667-7
[6]	WANG X, HUANG Y, ZHOU B, et al. Improvement of quality and flavor of salted egg yolks by ultrasonic assisted cooking[J]. Ultrasonics Sonochemistry,2021,75:105579. doi: 10.1016/j.ultsonch.2021.105579
[7]	李子康. 低量钙镁盐与钾盐对咸蛋腌制影响[J]. 广东化工,2019,46(13):65−67. [LI Zikang. Effect of low calcium magnesium salt and potassium salt on salted eggs[J]. Guangdong Chemistry Industry,2019,46(13):65−67. doi: 10.3969/j.issn.1007-1865.2019.13.031
[8]	XU L, ZHAO Y, XU M, et al. Effects of salting treatment on the physicochemical properties, textural properties, and microstructures of duck eggs[J]. Plos One,2017,12(8):e182912.
[9]	HARLINA P W, SHAHZAD R, MA M, et al. Effects of galangal extract on lipid oxidation, antioxidant activity and fatty acid profiles of salted duck eggs[J]. Journal of Food Measurement and Characterization,2019,13(3):1820−1830. doi: 10.1007/s11694-019-00100-z
[10]	杜金平. 鸭蛋加工技术与质量控制: 第八届(2019)中国水禽发展大会暨第二届鸭饲料营养与养殖技术研讨会[C]. 中国广东云浮, 2019. DU Jinping. Duck egg processing technology and quality control: The 8th (2019) China waterfowl development conference and the 2nd symposium on duck feed nutrition and breeding technology[C]. China Guangdong Yunfu, 2019.
[11]	戴幽. 咸蛋黄硬心现象形成原因初探[D]. 长沙: 湖南农业大学, 2020. DAI You. A preliminary study on the causes of the formation of salted egg yolk hard heart[D]. Changsha: Hunan Agriculture University, 2020.
[12]	王梦林. 优质咸蛋黄腌制新工艺及品质分析[D]. 南昌: 南昌大学, 2015. WANG Menglin. Study on new pickling technique of high quality salted egg yolk and its quality analysis[D]. Nanchang: Nanchang University, 2015.
[13]	刘蒙佳, 周强, 刘禹. 腌制条件对咸鸭蛋品质的影响及熟化工艺研究[J]. 中国调味品,2019,44(1):50−53. [LIU Mengjia, ZHOU Qiang, LIU Yu. Effect of curing conditions on quality of salted duck eggs and research on the maturation process[J]. China Condiment,2019,44(1):50−53. doi: 10.3969/j.issn.1000-9973.2019.01.011
[14]	龙门, 宋野, 杜庆飞, 等. 腌制温度和食盐用量对咸鸭蛋蛋黄脂质的影响[J]. 农业工程学报,2015,31(18):281−288. [LONG Men, SONG Ye, DU Qingfei, et al. Study on the variation of relevant indicators and selection of the optimum formula in pickling process of salted duck egg[J]. Guangdong Agricultural Sciences,2015,31(18):281−288. doi: 10.11975/j.issn.1002-6819.2015.18.038
[15]	中华人民共和国国家卫生和计划生育委员会, 国家食品药品监督管理总局. GB 5009.91-2017食品安全国家标准食品中钾、钠的测定[S]. 北京: 中国标准出版社, 2017. National Health and Family Planning Commission of the People's Republic of China, State Food and Drug Administration. GB 5009.91-2017 National standard of food safety Determination of potassium and sodium in food[S]. Beijing: Standards Press of China, 2017.
[16]	中华人民共和国国家卫生和计划生育委员会, 国家食品药品监督管理总局. GB 5009.3-2016食品安全国家标准食品中水分的测定[S]. 北京: 中国标准出版社, 2016. National Health and Family Planning Commission of the People's Republic of China, State Food and Drug Administration. GB 5009.3-2016 National standard of food safety Determination of water in food[S]. Beijing: Standards Press of China, 2016.
[17]	曾舟, 马美湖, 何兰, 等. 不同腌制添加剂对咸蛋腌制效果的影响[J]. 中国食品学报,2012,12(10):140−148. [ZENG Zhou, MA Meihu, HE Lan, et al. Effect of different pickle additives on preserved salted egg[J]. Journal of Chinese Institute of Food Science and Technology,2012,12(10):140−148.
[18]	LAI K M, CHUNG W H, JAO C L, et al. Oil exudation and histological structures of duck egg yolks during brining[J]. Poult Sci,2010,89(4):738−744. doi: 10.3382/ps.2009-00334
[19]	中华人民共和国国家卫生和计划生育委员会, 国家食品药品监督管理总局. GB 5009.5-2016食品安全国家标准食品中蛋白质的测定[S]. 北京: 中国标准出版社, 2016. National Health and Family Planning Commission of the People's Republic of China, State Food and Drug Administration. GB 5009.5-2016 National standard of food safety Determination of protein in food[S]. Beijing: Standards Press of China, 2016.
[20]	BEVERIDGE T, TOMA S J, NAKAI S. Determination of SH and SS groups in some food proteins using Ellman's reagent[J]. Journal of Food Science,1974,39(1):49−51. doi: 10.1111/j.1365-2621.1974.tb00984.x
[21]	HIDAS K I, NYULAS-ZEKE I C, VISY A, et al. Effect of combination of salt and pH on functional properties of frozen-thawed egg yolk[J]. Agriculture,2021,11(3):257. doi: 10.3390/agriculture11030257
[22]	TANG H G, TAN L, CHEN Y, et al. Effect of k-carrageenan addition on protein structure and gel properties of salted duck egg white[J]. Journal of the Science of Food and Agriculture,2021,101(4):1389−1395. doi: 10.1002/jsfa.10751
[23]	LIU Y, MA Y, CHI Y, et al. Change in rapid salting kinetics and characteristics of hen egg yolks[J]. Journal of Food Engineering,2022,329:111090. doi: 10.1016/j.jfoodeng.2022.111090
[24]	荣建华, 张正茂, 冯磊, 等. 咸蛋盐水腌制动力学研究[J]. 农业工程学报,2007(2):263−266. [RONG Jianhua, ZHANG Zhengmao, FENG Lei, et al. Pickling dynamics of salted egg[J]. Transactions of the CSAE,2007(2):263−266. doi: 10.3321/j.issn:1002-6819.2007.02.051
[25]	ANTON M, LE DENMAT M, BEAUMAL V, et al. Filler effects of oil droplets on the rheology of heat-set emulsion gels prepared with egg yolk and egg yolk fractions[J]. Colloids Surf B Biointerfaces,2001,21(1-3):137−147. doi: 10.1016/S0927-7765(01)00167-9
[26]	ZHAO Y, FENG F, YANG Y, et al. Gelation behavior of egg yolk under physical and chemical induction: A review[J]. Food Chemistry,2021,355:129569. doi: 10.1016/j.foodchem.2021.129569
[27]	何家林, 欧阳玲花, 付晓记, 等. 有机酸预处理对腌制咸蛋的影响[J]. 江西农业学报,2015,27(11):61−63. [HE Jialin, OUYANG Linghua, FU Xiaoji, et al. Effect of pretreatment with organic acids on salted duck eggs[J]. Acta Agriculturae Jiangxi,2015,27(11):61−63. doi: 10.3969/j.issn.1001-8581.2015.11.015
[28]	VENKATACHALAM K. Influence of prolonged salting on the physicochemical properties of duck egg white[J]. Brazilian Archives of Biology and Technology, 2018, 61.
[29]	YUAN L, ZHANG J, WU J, et al. The effect on quality of pickled salted duck eggs using the novel method of pulsed pressure osmotic dehydration[J]. Journal of Food Processing and Preservation,2018,42(4):e13581. doi: 10.1111/jfpp.13581
[30]	孙秀秀, 何立超, 杨海燕, 等. 间歇超声辅助加快咸蛋腌制速度工艺优化[J]. 食品工业科技,2018,39(22):204−211. [SUN Xiuxiu, HE Lichao, YANG Haiyan, et al. Intermittent ultrasound assisted in speeding up the pickling speed of salted eggs[J]. Science and Techology of Food Industry,2018,39(22):204−211.
[31]	XU L, ZHAO Y, XU M, et al. Changes in aggregation behavior of raw and cooked salted egg yolks during pickling[J]. Food Hydrocolloids,2018,80:68−77. doi: 10.1016/j.foodhyd.2018.01.026
[32]	郑华, 彭辉, 林捷, 等. 食盐对咸蛋黄蛋白质特性的影响[J]. 食品科学,2013,34(1):83−87. [ZHENG Hua, PENG Hui, LIN Jie, et al. Effect of salt on properties of salted yolk protein[J]. Food Science,2013,34(1):83−87.
[33]	ULRICHS T, DROTLEFF A M, TERNES W. Determination of heat-induced changes in the protein secondary structure of reconstituted livetins (water-soluble proteins from hen’s egg yolk) by FTIR[J]. Food Chemistry,2015,172:909−920. doi: 10.1016/j.foodchem.2014.09.128
[34]	谢云霄, 耿放, 王金秋. 蛋黄主要蛋白质研究进展[J]. 食品工业,2019,40(7):266−270. [XIE Yunxiao, GENG Fang, WANG Jinqiu. Research advances in the major proteins of egg yolk[J]. The Food Industry,2019,40(7):266−270.
[35]	徐丽兰, 赵燕, 徐明生, 等. 食盐诱导的蛋黄凝聚行为研究进展[J]. 中国食品学报,2019,19(3):317−325. [XU Lilan, ZHAO Yan, XU Mingsheng, et al. Research progress in the aggregation behavior of egg yolk induced by salt[J]. Journal of Chinese Institute of Food Science and Technology,2019,19(3):317−325.
[36]	杨海燕, 金永国, 孙秀秀, 等. 添加不同水平NaCl对蛋黄浆质凝胶性的影响研究[J]. 现代食品科技,2018,34(8):165−171. [YANG Haiyan, JIN Yongguo, SUN Xiuxiu, et al. Effects of different NaCl addition levels on the gel properties of egg yolk plasma[J]. Modern Food Science and Technology,2018,34(8):165−171.
[37]	张根生, 俆旖梦, 遇仕友, 等. 蛋黄凝胶形成机理及影响因素研究进展[J]. 食品与机械,2021,37(4):1−5. [ZHANG Gengsheng, XU Yimeng, YU Shiyou, et al. Research progress on formation mechanism and influencing factors of egg yolk gel[J]. Food and Machinery,2021,37(4):1−5.