Effects of Different Drying Methods on Lipid Oxidation and Volatile Flavor Components of Spanish Mackerel (<i>Scomberomorus niphonius</i>)

CUI Kexin; SUN Yong; TONG Lihui; YU Ying; ZHANG Jin; WANG Mingli; FU Yunhong; ZHOU Deqing; WANG Dajun; LIU Nan

doi:10.13386/j.issn1002-0306.2022040209

Volume 44 Issue 5

Feb. 2023

Turn off MathJax

Article Contents

Abstract

References

Science and Technology of Food Industry > 2023 > 44(5): 10-20. > DOI: 10.13386/j.issn1002-0306.2022040209

CUI Kexin, SUN Yong, TONG Lihui, et al. Effects of Different Drying Methods on Lipid Oxidation and Volatile Flavor Components of Spanish Mackerel (Scomberomorus niphonius)[J]. Science and Technology of Food Industry, 2023, 44(5): 10−20. (in Chinese with English abstract). doi: 10.13386/j.issn1002-0306.2022040209.

Citation:

PDF (2193 KB)

Effects of Different Drying Methods on Lipid Oxidation and Volatile Flavor Components of Spanish Mackerel (Scomberomorus niphonius)

1.
Yellow Sea Fisheries Institute, Chinese Academy of Fishery Sciences, Laboratory for Marine Drugs and Bioproducts of Pilot National Laboratory for Marine Science and Technology, Qingdao 266071, China
2.
Penglai Huiyang Food Co., Ltd., Yantai 264000, China
3.
Yantai Haiyu Food Co., Ltd., Yantai 264000, China

More Information

Received Date: April 18, 2022
Available Online: December 30, 2022

Graphical Abstract

Abstract

Abstract

To explore the effects of different drying methods on lipid oxidation and volatile flavor components of fishery products, the corresponding experimental groups were prepared by hot-air drying, cold-air drying and traditional natural drying using fresh Spanish mackerel (Scomberomorus niphonius) as raw material. The moisture content, pH value, lipid content, acid value (AV), peroxide value (POV), malondialdehyde (MDA), fatty acid composition and volatile flavor components of raw materials and different dried samples were measured. The results showed that the moisture content of dried samples prepared by three drying methods was about 30% with the pH value above 6. The AV, POV and the contents of MDA in the cold-air drying group were lower than the other groups (P<0.05). In the hot-air drying group, the lipid content decreased the most, and the AV was the highest, the POV and the content of MDA were significantly lower than those of natural drying group (P<0.05). The AV of the natural drying group represented the lowest, the POV and the content of MDA were significantly higher than those of other groups (P<0.05). The content of unsaturated fatty acid, especially the ω-3 polyunsaturated fatty acids decreased significantly (P<0.05), especially in the natural drying group. A total of 120 volatile flavor substances in 8 categories were detected from raw materials and drying samples, mainly composed of aldehydes, alcohols and esters. Principal component analysis revealed that the cumulative contribution rate of the 3 principal components to flavor was 99.9%, and the score of the natural drying group was the highest. The results indicated that the different drying methods had a great influence on the degree of lipid oxidation and flavor of Spanish mackerel, and the natural drying group had the best flavor. This research provides effective data support and development direction for the technological transformation of the traditional aquatic product processing industry.
- fishery products,
- Scomberomorus niphonius,
- lipid oxidation,
- volatile flavor components,
- drying methods

FullText(HTML)

References (35)

References

[1]	WAN R, SONG P B, LI Z G, et al. Distribution and environmental characteristics of the spawning grounds of Scomberomorus niphonius in the coastal waters of Yellow Sea, China[J]. Chinese Journal of Applied Ecology,2020,31(1):275−281.
[2]	祖凯伟, 程家骅, 刘阳, 等. 产卵期及越冬期蓝点马鲛渔场分布变化及其与海表温度的关系[J]. 海洋湖沼通报,2019(6):48−57. [ZU K W, CHENG J Y, LIU Y, et al. Distribution of fishing grounds of Japanese Spanish mackerel (Scomberomorus niphonius) during spawning and overwintering period and its relation with sea surface temperature in China sea[J]. Transactions of Oceanology and Limnology,2019(6):48−57.
[3]	HUANG Y Z, LIU Y, JIN Z, et al. Sensory evaluation of fresh/frozen mackerel products: A review[J]. Comprehensive Reviews in Food Science and Food Safety,2021,20(4):3504−3530. doi: 10.1111/1541-4337.12776
[4]	SVEINSDÓTTIR H I, KARLSDÓTTIR M G, ARASON S, et al. Effect of antioxidants on the sensory quality and physicochemical stability of Atlantic mackerel (Scomber scombrus) fillets during frozen storage[J]. Food Chemistry,2020,321:126744. doi: 10.1016/j.foodchem.2020.126744
[5]	王玉, 赵延宁, 薛勇, 等. 基于电子鼻与SPME-GC-MS法分析咸鲅鱼加工过程挥发性风味成分变化[J]. 食品工业科技,2018,39(24):266−272. [WANG Y, ZHAO Y N, XUE Y, et al. Analysis of volatile flavor compounds changes during salted Spanish mackerel processing by electronic nose and SPME-GC-MS[J]. Science and Technology of Food Industry,2018,39(24):266−272.
[6]	王玉, 王睿迪, 薛勇, 等. 传统加工咸鲅鱼的挥发性风味成分[J]. 现代食品科技,2018,34(9):268−276. [WANG Y, WANG Y D, XUE Y, et al. Analysis of volatile flavor compounds changes during traditional processing of salted Spanish mackerel[J]. Modern Food Science and Technology,2018,34(9):268−276.
[7]	赵延宁, 王玉, 王睿迪, 等. 市售咸干鲅鱼的安全性分析[J]. 食品与发酵工业,2019,45(14):215−220. [ZHAO Y N, WANG Y, WANG R D, et al. Safety analysis of commercially available salted and dried Spanish markerel[J]. Food and Fermentation Industries,2019,45(14):215−220. doi: 10.13995/j.cnki.11-1802/ts.019258
[8]	中华人民共和国国家卫生健康委员会. GB 5009.3-2016 食品安全国家标准食品中水分的测定[S]. 北京: 中国标准出版社, 2016: 1−4 National Health and Wellness Commission of the People's Republic of China. GB 5009.3-201 National standard for food safety determination of moisture in food[S]. Beijing: China Standards Press, 2016: 1−4.
[9]	VIDAL V A S, SANTANA J B, PAGLARINI C S, et al. Adding lysine and yeast extract improves sensory properties of low sodium salted meat[J]. Meat Science,2020:159. doi: 10.1016/j.meatsci.2019.107911
[10]	中华人民共和国国家卫生健康委员会. GB 5009.6-2016食品安全国家标准食品中脂肪的测定[S]. 北京: 中国标准出版社, 2016: 3−5 National health and Wellness Commission of the People's Republic of China. GB 5009.6-2016 National standard for food safety determination of fat in food[S]. Beijing: China Standards Press, 2016: 3−5.
[11]	PHUNG A S, BANNENBERG G, VIGOR C, et al. Chemical compositional changes in over-oxidized fish oils[J]. Foods,2020,9(10):1501−1532. doi: 10.3390/foods9101501
[12]	中华人民共和国国家卫生健康委员会. GB 5009.227-2016食品安全国家标准食品中过氧化值的测定[S]. 北京: 中国标准出版社, 2016: 1−4 National Health and Wellness Commission of the People's Republic of China. GB 5009.227-2016 National standard for food safety determination of peroxide value in food[S]. Beijing: China Standards Press, 2016: 1−4.
[13]	中华人民共和国国家卫生健康委员会. GB 5009.181-2016食品安全国家标准食品中丙二醛的测定[S]. 北京: 中国标准出版社, 2016: 1−3 National Health and Wellness Commission of the People's Republic of China. GB 5009.168-2016 National standard for food safety determination of malonaldehyde in food[S]. Beijing: China Standards Press, 2016: 1−3.
[14]	中华人民共和国国家卫生健康委员会. GB 5009.168-2016食品安全国家标准食品中脂肪酸的测定[S]. 北京: 中国标准出版社, 2016: 10-11 National Health and Wellness Commission of the People's Republic of China. GB 5009.168-2016 National standard for food safety determination of fatty acids in food[S]. Beijing: China Standards Press, 2016: 10-11.
[15]	YU H, XIE T, XIE J, et al. Characterization of key aroma compounds in Chinese rice wine using gas chromatography-mass spectrometry and gas chromatography-olfactometry[J]. Food Chemistry,2019,293:8−14. doi: 10.1016/j.foodchem.2019.03.071
[16]	余静, 张佳敏, 王卫, 等. 干燥工艺对腌腊鱼品质特性的影响[J]. 食品研究与开发,2019,40(12):95−102. [YU J, ZHANG J M, WANG W, et al. Effect of drying process on quality characteristics of salted fish[J]. Food Research and Development,2019,40(12):95−102. doi: 10.3969/j.issn.1005-6521.2019.12.016
[17]	顾赛麒, 周洪鑫, 郑皓铭, 等. 干制方式对腌腊草鱼脂肪氧化和挥发性风味成分的影响[J]. 食品科学,2018,39(21):1−10. [GU S Q, ZHOU H X, ZHENG H M, et al. Effects of different drying methods on lipid oxidation and volatile flavor components of cured grass carp[J]. Food Science,2018,39(21):1−10. doi: 10.7506/spkx1002-6630-201821001
[18]	WANG Z, HE Z, GAN X, et al. Interrelationship among ferrous myoglobin, lipid and protein oxidations in rabbit meat during refrigerated and super chilled storage[J]. Meat Science,2018,146:131−139. doi: 10.1016/j.meatsci.2018.08.006
[19]	顾赛麒, 鲍嵘斌, 冯媛, 等. 肉类和水产制品脂质光氧化机制及其影响因素[J]. 食品与发酵工业,2021,47(24):271−278. [GU S Q, BAO R B, FENG Y, et al. Mechanism and influencing factors of lipid photooxidation in meat and aquatic products[J]. Food and Fermentation Industries,2021,47(24):271−278.
[20]	顾赛麒, 唐锦晶, 周绪霞, 等. 腌腊鱼传统日晒干制过程中品质变化与香气形成[J]. 食品科学,2019,40(17):36−44. [GU S Q, TANG J J, ZHOU X X, et al. Quality change and aroma formation in cured fish during traditional sun drying processing[J]. Food Science,2019,40(17):36−44. doi: 10.7506/spkx1002-6630-20180716-201
[21]	高海, 蔡欢欢, 朱志伟. 光照和温度对草鱼和三文鱼鱼肉贮藏品质的影响[J]. 食品科学,2017,38(15):244−249. [GAO H, CAI H H, ZHU Z W. Comparative study of effects of light exposure and storage temperature on the quality of grass carp fillets and salmon fillets[J]. Food Science,2017,38(15):244−249. doi: 10.7506/spkx1002-6630-201715039
[22]	CHEN J, LI J, LIU X, et al. Effects of dietary fat saturation level on growth performance, carcass traits, blood lipid parameters, tissue fatty acid composition and meat quality of finishing pigs[J]. Animal Bioscience,2021,34(5):895−903. doi: 10.5713/ajas.20.0247
[23]	NAIN C W, BERDAL G, THAO P T P, et al. Green tea extract enhances the oxidative stability of DHA-rich oil[J]. Antioxidants (Basel),2021,10(6):982. doi: 10.3390/antiox10060982
[24]	刘梦, 史智佳, 杨震. 不同热加工温度对牛肉干脂肪酸及脂肪氧化的影响[J]. 肉类研究,2019,33(2):1−6. [LIU M, SHI Z J, YANG Z. Effects of different thermal processing temperatures on fatty acid composition and fat oxidation of beef jerky[J]. Meat Research,2019,33(2):1−6. doi: 10.7506/rlyj1001-8123-20181228-242
[25]	刘昌华. 鲈鱼风干成熟工艺及其脂质分解氧化和风味品质特性研究[D]. 南京: 南京农业大学, 2012. LIU C H. Study on drying-raping process of perches, lipolysis-lipid oxidation and flavor character during processing[D]. Nanjing: Nanjing Agricultural University, 2012.
[26]	BATEN M A, WON N E, MOHIBBULLAH M, et al. Effect of hot smoking treatment in improving sensory and physicochemical properties of processed Japanese Spanish mackerel Scomberomorus niphonius[J]. Food Science & Nutrition,2020,8(7):3957−3968.
[27]	WU S, YANG J, DONG H, et al. Key aroma compounds of Chinese dry-cured Spanish mackerel (Scomberomorus niphonius) and their potential metabolic mechanisms[J]. Food Chemistry,2021,342:128381. doi: 10.1016/j.foodchem.2020.128381
[28]	CAO J, JIANG X, CHEN Q, et al. Oxidative stabilities of olive and camellia oils: Possible mechanism of aldehydes formation in oleic acid triglyceride at high temperature[J]. LWT-Food Science and Technology,2020,118:108858. doi: 10.1016/j.lwt.2019.108858
[29]	雷乙, 陈竟豪, 涂金金, 等. 鱼肉加工过程特征气味物质变化研究进展[J]. 食品研究与开发,2020,41(15):201−210. [LEI Y, CHEN J H, TU J J, et al. Research progress on changes of characteristic odor substances in fish processing[J]. Food Research and Development,2020,41(15):201−210. doi: 10.12161/j.issn.1005-6521.2020.15.034
[30]	KIM J Y, KIM M J, LEE J. Role of moisture on the lipid oxidation determined by D(₂)O in a linoleic acid model system[J]. Food Chemistry,2014,146:134−40. doi: 10.1016/j.foodchem.2013.09.025
[31]	GIMÉNEZ B, GÓMEZ-GUILLÉN M C, PÉREZ-MATEOS M, et al. Evaluation of lipid oxidation in horse mackerel patties covered with borage-containing film during frozen storage[J]. Food Chemistry,2011,124(4):1393−1403. doi: 10.1016/j.foodchem.2010.07.097
[32]	李松林, 蒋长兴, 聂凌鸿, 等. 风鸡腌制和风干过程中挥发性成分的变化[J]. 食品与发酵工业,2015,41(3):191−198. [LI S L, JIANG C X, NIE L H, et al. Changes of volatile compounds during curing and drying of air-dried chicken[J]. Food and Fermentation Industries,2015,41(3):191−198. doi: 10.13995/j.cnki.11-1802/ts.201503034
[33]	LIU Y, WAN Z, YOHANNES K W, et al. Functional characteristics of lactobacillus and yeast single starter cultures in the ripening process of dry fermented sausage[J]. Frontier Microbiology,2021,11:611260. doi: 10.3389/fmicb.2020.611260
[34]	WANG M Q, MA W J, SHI J, et al. Characterization of the key aroma compounds in Longjing tea using stir bar sorptive extraction (SBSE) combined with gas chromatography-mass spectrometry (GC-MS), gas chromatography-olfactometry (GC-O), odor activity value (OAV), and aroma recombination[J]. Food Research International,2020,130:108908. doi: 10.1016/j.foodres.2019.108908
[35]	GUO H, CHEN C, LEE D J. Nitrogen and sulfur metabolisms of Pseudomonas sp. C27 under mixotrophic growth condition[J]. Bioresource Technology,2019,293:122169. doi: 10.1016/j.biortech.2019.122169

Supplements (0)

Cited By

Cited by

Periodical cited type(6)

1.	顾宇翔，周羽，刘恕. 护肤类化妆品功效评价理化试验方法的现状和分析. 日用化学工业(中英文). 2024(06): 727-732 .
2.	岳开妍，毛丙永，唐鑫，张秋香，赵建新，崔树茂. 乳酸菌发酵对花生衣抗糖化缓解皮肤衰老功能的影响. 上海理工大学学报. 2024(04): 364-374 .
3.	王国凯，龚荣英，杨灵丽，刘文龙，晋海军，田维毅. 槐花水提液发酵工艺优化及其抗氧化活性分析. 食品工业科技. 2024(20): 196-204 . 本站查看
4.	夏俊英，余海霞，戚仕梅，张富娜，邬婧，肖卫华. 长双歧杆菌胞外多糖对非酶糖基化的抑制作用. 生物学杂志. 2024(05): 6-13+47 .
5.	谢圆芳，袁道欢，张丽山，黄嘉敏，林霁，田佳佳，贺锐，解勇. 黑松露提取物紧致抗皱功效. 香料香精化妆品. 2024(05): 73-77+149 .
6.	曾贝贝，吕静，鲁杏茹，智文博，李带根. 牡丹花酶解肽的理化性质及促进皮肤健康功效. 食品工业科技. 2024(22): 314-321 . 本站查看