Effects of Short- and Medium-wave Infrared Radiation Drying on Drying Characteristics, Nutritional Quality and Antioxidant Activity of Mulberry

LIU Qiling; WANG Qingwei

doi:10.13386/j.issn1002-0306.2020090209

Volume 42 Issue 12

Jun. 2021

Turn off MathJax

Article Contents

Abstract

References

Science and Technology of Food Industry > 2021 > 42(12): 39-45. > DOI: 10.13386/j.issn1002-0306.2020090209

LIU Qiling, WANG Qingwei. Effects of Short- and Medium-wave Infrared Radiation Drying on Drying Characteristics, Nutritional Quality and Antioxidant Activity of Mulberry[J]. Science and Technology of Food Industry, 2021, 42(12): 39−45. (in Chinese with English abstract). doi: 10.13386/j.issn1002-0306.2020090209.

Citation:

PDF (845 KB)

Effects of Short- and Medium-wave Infrared Radiation Drying on Drying Characteristics, Nutritional Quality and Antioxidant Activity of Mulberry

Zhengzhou University of Industry Technology, Xinzheng 451100, China

More Information

Received Date: September 20, 2020
Available Online: April 14, 2021

Graphical Abstract

Abstract

Abstract

In order to explore the effects of short-and medium-wave infrared radiation drying on the drying characteristics, energy consumption, nutritional quality and antioxidant activity of mulberry, fresh mulberry was dried by short- and medium-wave infrared radiation drying at different drying temperatures (50, 60, 70 ℃), and compared with hot air drying under the same drying temperature (50, 60, 70 ℃), the drying characteristics, energy consumption, contents of phenolic monomers, total phenols, total flavonoids, vitamin C, total anthocyanin and antioxidant activity of mulberry under different drying conditions were investigated, and the short- and medium-wave infrared drying mathematical model of mulberry fruit was established. The results showed that the short- and medium-wave infrared radiation drying could significantly improve the drying efficiency of mulberry (the drying efficiency increased by 55.7% at 50 ℃, 46.1% at 60 ℃, and 33.3% at 70 ℃), and the Weibull distribution model could well simulate the drying process of short- and medium-wave infrared radiation drying at different drying temperatures. In addition, the energy consumption of mulberry dried by medium and short wave infrared was lower. Twelve phenolic substances were detected in dried mulberry fruit, among which chlorogenic acid, rutin and catechin were the main phenolic substances. Compared with the traditional hot air drying, the short-and medium-wave infrared radiation drying had higher drying efficiency, higher contents of total phenols, total flavonoids, vitamin C and total anthocyanins, the total phenol content was 463.1~568.8 mg/100 g. The total flavonoids content was 312.6~402.6 mg/100 g. The contents of vitamin C was 30.1~37.8 mg/100 g. The total anthocyanin content was 153.6~195.6 mg/100 g. In addition, compared with hot air drying, the antioxidant activity of mulberry fruit was significantly enhanced after short- and medium-wave infrared radiation drying (DPPH free radical scavenging ability was improved by 32.8% to 42.6% compared with hot air drying). Compared with hot air drying, iron ion reduction ability was improved by 21.1%~34.1%), short- and medium-wave infrared radiation drying of mulberry fruit had higher drying efficiency, lower energy consumption and better quality of dried products. Therefore, short- and medium-wave infrared radiation drying was an excellent drying way of mulberry fruit, which could provide theoretical reference for the dried processing of mulberry fruit.
- mulberry,
- short- and medium-wave infrared radiation drying,
- drying characteristics,
- mulberry quality,
- antioxidant activity

FullText(HTML)

References (32)

References

[1]	孙乐, 张小东, 郭迎迎. 桑葚的化学成分和药理作用研究进展[J]. 人参研究,2016,28(2):49−54. doi: 10.3969/j.issn.1671-1521.2016.02.015
[2]	Chen C C, Liu L K, Hsu J D, et al. Mulberry extract inhibits the development of atherosclerosis in cholesterol-fed rabbits[J]. Food Chemistry,2005,91(4):601−607. doi: 10.1016/j.foodchem.2004.06.039
[3]	Wasim M , Daud M , Arif M , et al. Characterisation of some exotic fruits (Morus nigra, Morus alba, Salvadora persica and Carissa opaca) used as herbal medicines by neutron activation analysis and estimation of their nutritional value[J]. Journal of Radioanalytical & Nuclear Chemistry,2012,292(2):653−659.
[4]	Chen Q Q, Li Z L, Bi J F, et al. Effect of hybrid drying methods on physicochemical, nutritional and antioxidant properties of dried black mulberry[J]. LWT-Food Science and Technology,2017,80:178−184. doi: 10.1016/j.lwt.2017.02.017
[5]	郭婷, 吴燕, 陈益能, 等. 热风干燥温度对大果山楂干燥产品品质的影响[J]. 食品工业,2020,41(8):184−188.
[6]	Wang J M, Wu G X, Wang Z N, et al. The influence of processing conditions on kinetics, anthocyanin profile and antioxidant activity of purple sweet potato subjected to hot air drying[J]. Journal of Food Process Engineering,2020,43(9):e13472.
[7]	高静静, 冯作山, 白羽嘉. 真空冷冻和热风干燥对哈密瓜片品质的影响[J]. 保鲜与加工,2020,36(3):78−84. doi: 10.3969/j.issn.1009-6221.2020.03.012
[8]	Aneta W, Adam F, Pilar L, et al. Chemical composition, antioxidant capacity, and sensory quality of dried jujube fruits as affected by cultivar and drying method[J]. Food Chemistry,2016,207(15):170−179.
[9]	Huang L L, Zhang M, Yan W Q, et al. Effect of coating on post-drying of freeze-dried strawberry pieces[J]. Journal of Food Engineering,2009,92(1):107−111. doi: 10.1016/j.jfoodeng.2008.10.031
[10]	Swasdisevi T, Devahastin S, Sa-Adchom P, et al. Mathematical modeling of combined far-infrared and vacuum drying banana slice[J]. Journal of Food Engineering,2009,92(1):100−106. doi: 10.1016/j.jfoodeng.2008.10.030
[11]	Chen Q, Bi J, Wu X, et al. Drying kinetics and quality attributes of jujube (Zizyphus jujuba Miller) slices dried by hot-air and short- and medium-wave infrared radiation[J]. LWT - Food Science and Technology,2015,64(2):759−766. doi: 10.1016/j.lwt.2015.06.071
[12]	游庭活, 温露, 刘凡, 等. 不同干燥方式及温度条件对桑椹干营养保健品质的影响[J]. 蚕业科学,2015,41(5):921−927.
[13]	李斌, 王夷秀, 毕金峰, 等. 热风与中短波红外泡沫干燥对桑葚粉品质的影响[J]. 食品科学,2017,38(17):47−52.
[14]	Kipcak A S, Doymaz I. Mathematical modeling and drying characteristics investigation of black mulberry dried by microwave method[J]. International Journal of Fruit hence,2020,4:1−12.
[15]	Zhu B M, Wu X S, Wang G D. Effect of pre-treatments on drying characteristics of Chinese jujube (Zizyphus jujuba Miller)[J]. International Journal of Agricultural & Biological Engineering,2014,7(1):94−102.
[16]	Kwaw E, Ma Y, Tchabo W, et al. Impact of ultrasonication and pulsed light treatments on phenolics concentration and antioxidant activities of lactic-acid-fermented mulberry juice[J]. LWT-Food Science and Technology,2018,92:61−66. doi: 10.1016/j.lwt.2018.02.016
[17]	Suênia G, Gonalves M, Borgess G, et al. Effects of probiotics on the content and bioaccessibility of phenolic compounds in red pitaya pulp[J]. Food Research International,2019,126:108681. doi: 10.1016/j.foodres.2019.108681
[18]	Natic M M, Dabic D C, Papetti A, et al. Analysis and characterisation of phytochemicals in mulberry (Morus alba L.) fruits grown in Vojvodina, North Serbia[J]. Food Chemistry,2015,171:128−136. doi: 10.1016/j.foodchem.2014.08.101
[19]	Rahman M M, Khan M R, Hosain M M. Analysis of vitamin C (ascorbic acid) contents in various fruits and vegetables by UV-spectrophotometry[J]. Bangladesh Journal of Scientific & Industrial Research,2008,42(4):417−424.
[20]	Kou X H, Chen Q, Li X H, et al. Quantitative assessment of bioactive compounds and the antioxidant activity of 15 jujube cultivars[J]. Food Chemistry,2015,173:1037−1044. doi: 10.1016/j.foodchem.2014.10.110
[21]	王招招, 路风银, 朱广成, 等. 花生果微波-热风耦合干燥特性及能耗分析[J]. 中国油料作物学报,2020,42(1):140−146.
[22]	Sarsavadia P N. Development of a solar-assisted dryer and evaluation of energy requirement for the drying of onion[J]. Renewable Energy,2007,32(15):2529−2547. doi: 10.1016/j.renene.2006.12.019
[23]	李聪, 周沫, 毕金峰, 等. 热风和中短波红外干燥对桃渣干燥特性及多酚含量的影响[J]. 现代食品科技,2017,33(12):137−144.
[24]	李妍, 刘学铭, 刘吉平, 等. 不同果桑品种桑椹成熟过程中非花青素酚类物质的含量变化[J]. 蚕业科学,2008,34(4):711−717.
[25]	Ibrahim K, Wei Z, Li K K, et al. Polyphenols of mulberry fruits as multifaceted compounds: Compositions, metabolism, health benefits, and stability-A structural review[J]. Journal of Function Food,2018,40:28−43. doi: 10.1016/j.jff.2017.10.041
[26]	Jin Q, Yang J, Ma L, et al. Comparison of polyphenol profile and inhibitory activities against oxidation and α-glucosidase in mulberry (genusMorus) cultivars from China[J]. Journal of Food Science,2015,80(11):C2440−C2451. doi: 10.1111/1750-3841.13099
[27]	Memon A A, Memon N, Luthria D L, et al. Phenolic acids profiling and antioxidant potential of mulberry (Morus laevigata W., Morus nigra L., Morus alba L.) leaves and fruits grown in Pakistan[J]. Polish Journal of Food and Nutrition ences,2010,60(1):25−32.
[28]	Mahmood T, Anwar F, Afzal N, et al. Influence of ripening stages and drying methods on polyphenolic content and antioxidant activities of mulberry fruits[J]. Journal of Food Measurement & Characterization,2017(1):1−9.
[29]	Wu C, Gao Q H, Guo X D, et al. Effect of ripening stage on physicochemical properties and antioxidant profiles of a promising table fruit ‘pear-jujube’ (Zizyphus jujuba Mill.)[J]. Scientia Horticulturae,2012,148:177−184. doi: 10.1016/j.scienta.2012.09.026
[30]	Horszwald A, Ulien H, Andlauer, W, et al. Characterisation of Aronia powders obtained by different drying processes[J]. Food Chemistry,2013,141(3):2858−2863. doi: 10.1016/j.foodchem.2013.05.103
[31]	Wojdyło A, Figiel A, Oszmianski J, et al. Effect of drying methods with the application of vacuum microwaves on the bioactive compounds, color, and antioxidant activity of strawberry fruits[J]. Journal of Agricultural and Food Chemistry,2009,57(4):1337−1343. doi: 10.1021/jf802507j
[32]	Xie P J, You F, Huang L X, et al. Comprehensive assessment of phenolic compounds and antioxidant performance in the developmental process of jujube (Ziziphus jujuba Mill.)[J]. Journal of Functional Foods,2017,36:233−242. doi: 10.1016/j.jff.2017.07.012

[1]	ZHANG Lijing, HUA Yufei, ZHANG Caimeng, KONG Xiangzhen, LI Xingfei, CHEN Yeming. Effects of Protein Content on the Texture, Rheological Properties and Microstructure of Stirred Soy Yogurt[J]. Science and Technology of Food Industry, 2024, 45(24): 118-124. DOI: 10.13386/j.issn1002-0306.2024030054
[2]	ZHAO Xiao, DU Kun, ZHANG Yuan. Effect of Inulin on the Texture, Rheological Properties, and Microstructure of Synbiotic Yogurt[J]. Science and Technology of Food Industry, 2023, 44(1): 72-77. DOI: 10.13386/j.issn1002-0306.2022030241
[3]	LIU Ran, ZENG Qinghua, LIANG Ming, WANG Lei, CHENG Shuang. Effects of Xanthan Gum on Rheological Properties and Microstructure of Soy Protein Isolate Gel[J]. Science and Technology of Food Industry, 2022, 43(4): 65-72. DOI: 10.13386/j.issn1002-0306.2021060103
[4]	HUANG Yan-ling, REN Hao-tian. Effect of Spray Drying Temperature on Microstructure of Enzyme-assisted Aqueous Extraction Soybean Concentrated Protein Powder[J]. Science and Technology of Food Industry, 2020, 41(24): 50-54. DOI: 10.13386/j.issn1002-0306.2020030225
[5]	QI Ming-ming, GUO Peng, WANG Chen-jie, DONG Shuang, MA Cheng-ye. Research Progress of the Effects of Extrusion on Microstructure and Physicochemical Properties of Starch[J]. Science and Technology of Food Industry, 2020, 41(5): 305-310. DOI: 10.13386/j.issn1002-0306.2020.05.050
[6]	ZHANG Xiao-hong, WAN Zhong-min, SUN Jun, CHEN Pei-dong, LIU Bing. Effect of microwave treatment on RVA spectrum characteristic values and microstructure of rice[J]. Science and Technology of Food Industry, 2017, (12): 87-91. DOI: 10.13386/j.issn1002-0306.2017.12.016
[7]	JIANG Yuan-yuan, YING Tie-jin. Research of additives on texture property and microstructure of Yuba[J]. Science and Technology of Food Industry, 2017, (08): 300-305. DOI: 10.13386/j.issn1002-0306.2017.08.050
[8]	XU Jing-bing, WANG Ren, YU Qiu-sheng, FENG Wei, WANG Li, LUO Xiao-hu, LI Ya-nan, ZHANG Ming-wei, CHEN Zheng-xing. Effect of protein content on the microstructure and functional properties of indica rice flour[J]. Science and Technology of Food Industry, 2016, (17): 59-63. DOI: 10.13386/j.issn1002-0306.2016.17.003
[9]	Effects of spice extract on the textural properties and microstructure of beef balls during frozen storage[J]. Science and Technology of Food Industry, 2013, (16): 300-303. DOI: 10.13386/j.issn1002-0306.2013.16.050
[10]	Research progress in improvement of gel strength of gelatin based on microstructure[J]. Science and Technology of Food Industry, 2013, (13): 395-399. DOI: 10.13386/j.issn1002-0306.2013.13.085

Supplements (0)

Cited By

Cited by

Periodical cited type(6)

1.	杜鑫，易珊珊，何家国，覃明丽，苏旭，陈绍辉，蒋金芳. 快速滤过型净化结合超高效液相色谱-串联质谱法测定茶叶中5种农药残留量. 云南师范大学学报(自然科学版). 2024(02): 54-60 .
2.	王瑞琛，张婷，伏广想，陈冠涛. 荧光碳量子点传感器检测食品中农药残留的研究进展. 中国食品添加剂. 2024(04): 295-299 .
3.	彭汝林，刘媛媛，李海波，杜业刚，罗淙岚，朱雨田. 液相色谱-串联三重四极杆质谱仪快速测定鱼腥草中152种农药残留. 粮食与油脂. 2024(12): 154-162 .
4.	袁列江，王秀，李政，朱礼，邓航. 快速滤过型净化法结合超高效液相色谱串联质谱法测定动物源性食品中四唑虫酰胺残留. 食品与机械. 2024(10): 46-52 .
5.	程似锦，李恒，谢裕. UPLC-MS/MS法测定加味藿香正气丸中29种禁用农药残留. 广东化工. 2023(18): 159-164 .
6.	杜鑫，何家国，易珊珊，陈绍辉. 快速滤过型净化结合超高效液相色谱-串联质谱法测定茶叶中氟虫腈及其代谢物残留量. 农药科学与管理. 2023(11): 35-44 .