赤藓糖醇对南美白对虾肉玻璃化转变温度与状态图的影响

赵亚; 张平平; 王淑敏; 石启龙

doi:10.13386/j.issn1002-0306.2016.20.054

赤藓糖醇对南美白对虾肉玻璃化转变温度与状态图的影响

山东理工大学农业工程与食品科学学院

基金项目:

国家自然科学基金项目(31171708)；

详细信息

作者简介:
赵亚(1974-),女,硕士,实验师,研究方向:农产品加工与贮藏,E-mail:zy0028014@sdut.edu.cn。;

石启龙(1974-),男,教授,研究方向:果蔬/水产品加工与贮藏,E-mail:qilongshi@sdut.edu.cn。;

中图分类号: TS254.4
计量
- 文章访问数: 257
- HTML全文浏览量: 61
- PDF下载量: 204
出版历程
- 收稿日期: 2016-05-05

Effects of erythritol on the glass transition temperature and state diagram of Penaeus vannamei meat

School of Agricultural Engineering and Food Science,Shandong University of Technology

摘要

摘要: 南美白对虾肉（PV）冻藏期间极易出现蛋白质变性,为提高虾肉贮藏稳定性,研究了PV与按虾肉质量添加5%赤藓糖醇的虾肉（PV-E）的吸附等温线;测定了PV与PV-E的玻璃化转变温度（Tg）和冻结点温度（TF）。采用Gordon-Taylor方程与Chen’s方程拟合数据,探讨添加赤藓糖醇对虾肉状态图的影响。结果表明,PV与PV-E水分吸附均为III型等温线,GAB模型为描述虾肉水分吸附特性的最适模型。PV与PV-E的Tg随着湿基含水率升高而降低;相同含水率时,PV-E的Tg高于PV。PV与PV-E的TF随着固形物含量的增加而降低。PV与PV-E最大冷冻浓缩溶液时的玻璃化转变温度T’g分别为-77.09℃和-62.23℃,与之对应的溶质含量分别为0.672 g/g和0.686 g/g。赤藓糖醇可作为一种新型抗冻剂,用于提高虾肉冻藏期间的贮藏稳定性。
- 赤藓糖醇 /
- 南美白对虾 /
- 玻璃化转变温度 /
- 状态图 /
- 贮藏稳定性
Abstract: Protein denaturation is liable to occur during frozen storage of Penaeus vannamei( PV) meat.The effect of addition of erythritol on the glass transition temperature( Tg) and state diagram of Penaeus vannamei meat were investigated to improve the storage stability of Penaeus vannamei meat. Moisture adsorption isotherms of PV and Penaeus vannamei meat with addition of 5%( w / w) erythritol( PV- E) were determined at 25 ℃ by the gravimetric method. Differential scanning calorimetry was used to determine the Tgand freezing point( TF) of samples equilibrated at various water activities.Gordon- Taylor equation and Chen's equation were employed to model the data of Tgand TF,especially.The adsorption behavior of PV and PV-E displayed III type isotherms.The GAB model satisfactorily described the adsorption behavior of PV and PV- E. Tgof PV and PV- E decreased with increasing moisture content and TFdecreased with increasing solid content. At a given moisture content,Tgof Penaeus vannamei meat increased with the addition of erythritol.The state diagram yielded maximally- freeze- concentrated solutes at 0.672 g / g and 0.686 g / g solids with the characteristic temperature of glass transition being-77.09 ℃ and-62.23 ℃ for PV,and PV- E,respectively.Erythritol could be used as a novel cryoprotective agent and the storage stability and shelf life of Penaeus vannamei meat could be observably improved by the addition of erythritol.
- Penaeus vannamei /
- erythritol /
- glass transition temperature /
- state diagram /
- storage stability

HTML全文

参考文献(20)

[1]	谢丽丹,李蕾蕾,王素英,等.冰温贮藏中南美白对虾特定腐败菌的分离鉴定及其腐败能力分析[J].食品工业科技,2016,37(5):171-176.
[2]	谢丽丹,李蕾蕾,王素英,等.低温贮藏南美白对虾特定腐败菌的分离鉴定及腐败能力分析[J].食品与发酵工业,2016,42(3):67-72.
[3]	Boonsumrej S,Chaiwanichsiri S,Tantratian S,et al.Effects of freezing and thawing on the quality changes of tiger shrimp(Penaeus monodon)frozen by air-blast and cryogenic freezing[J].Journal of Food Engineering,2007,80(1):292-299.
[4]	胡晓亮,王易芬,郑晓伟,等.抗冻剂在水产品冻藏中的应用研究[J].中国农学通报,2015,31(35):38-42.
[5]	Carvajal P A,Mac Donald G A,Lanier T C.Cryostabilization mechanism of fish muscle proteins by maltodextrins[J].Cryobiology,1999,38(1):16-26.
[6]	袁丽,高瑞昌,薛长湖,等.褐藻酸钠裂解物提高凡纳滨对虾保水性机理的研究[J].水产学报,2011,35(10):1547-1553.
[7]	马璐凯,张宾,王强,等.海藻糖、海藻胶及寡糖对南美白对虾蛋白质冷冻变性的抑制作用[J].现代食品科技,2014,30(6):140-145.
[8]	石启龙,赵亚,曹淑敏,等.糖类对南美白对虾肉玻璃化转变温度与状态图的影响[J].农业机械学报,2015,46(11):236-244.
[9]	Shi Q L,Lin W W,Zhao Y,et al.Thermal characteristics and state diagram of Penaeus vannamei meat with and without maltodextrin addition[J].Thermochimica Acta,2015,616:92-99.
[10]	杨柳,陈宇飞,张一.利用NMR研究赤藓糖醇对糙米面包贮藏期间保水性的影响[J].食品科学,2015,36(6):262-266.
[11]	石启龙,林雯雯,赵亚,等.冻干扇贝肉玻璃化转变温度与状态图研究[J].农业机械学报,2014,45(8):225-230.
[12]	van den Berg C,Bruin S.Water activity and its estimation in food systems:theoretical aspects[M].Rockland:Academic Press,New York,1981.
[13]	Brunnauer S,Emmentt P,Teller E.Adsorption of gases in multimolecular layers[J].Journal of the American Chemical Society,1938,60(2):309-319.
[14]	石启龙,林雯雯,赵亚.南美白对虾肉玻璃化转变温度测定的影响因素[J].现代食品科技,2014,30(11):48-52.
[15]	Gordon M,Taylor J S.Ideal copolymers and the second-order transitions of synthetic rubbers.1.Non-crystalline copolymers[J].Journal of Applied Chemistry,1952,2(9):493-500.
[16]	Vasquez C,Diza-Calderon P,Enrione J,et al.State diagram,sorption isotherm and color of blueberries as a function of water content[J].Thermochimica Acta,2013,570:8-15.
[17]	刘红英,高瑞昌,戚向阳.食品化学[M].北京:中国质检出版社,2013.
[18]	Knani S,Aouaini F,Bahloul N,et al.Modeling of adsorption isotherms of water vapor on Tunisian olive leaves using statistical mechanical formulation[J].Physica A:Statistical Mechanics and its Application,2014,400:57-70.
[19]	Shi Q L,Zhao Y,Chen H H,et al.Glass transition and state diagram for freeze-dried horse mackerel muscle[J].Thermochimica Acta,2009,493(1/2):55-60.
[20]	Roos Y H.Glass transition temperature and its relevance in food processing[J].Annual Review of Food Science and Technology,2010,1:469-496.