超高压对未漂洗金线鱼鱼糜凝胶特性的影响

张智铭; 仪淑敏; 李学鹏; 步营; 牟伟丽; 于建洋; 劳敏军; 励建荣

doi:10.13386/j.issn1002-0306.2019110262

超高压对未漂洗金线鱼鱼糜凝胶特性的影响

1. 渤海大学食品科学与工程学院, 生鲜农产品贮藏加工及安全控制技术国家地方联合工程研究中心, 海洋食品精深加工关键技术省部共建协同创新中心, 国家鱼糜及鱼糜制品加工技术研发分中心, 辽宁锦州 121013;
2. 蓬莱京鲁渔业有限公司, 山东烟台 265600;
3. 泰祥集团-荣成泰祥食品股份有限公司, 农业部冷冻调理海洋食品加工重点实验室, 山东威海 264309;
4. 浙江兴业集团有限公司, 浙江舟山 316100

基金项目:

国家重点研发计划资助（2018YFD0901004）。

详细信息

作者简介:
张智铭(1994-),男,硕士,研究方向:食品加工与安全,E-mail:zhangmibia@163.com。

通讯作者:
仪淑敏(1980-),女,博士,教授,研究方向:水产品加工与质量安全控制,E-mail:yishumin@163.com

励建荣(1964-),男,博士,教授,研究方向:水产品加工与质量安全控制,E-mail:lijr6491@163.com。

中图分类号: TS254.1
计量
- 文章访问数: 324
- HTML全文浏览量: 36
- PDF下载量: 27
出版历程
- 收稿日期: 2019-11-27
- 网络出版日期: 2021-01-07
- 刊出日期: 2020-12-31

Effect of Ultra-high Pressure on Gel Properties of Unwashed Nemipterus virgatus Surimi

1. College of Food Science and Technology, Bohai University, National&Local Joint Engineering Research Center of Storage, Processing and Safety Control Technology for Fresh Agricultural and Aquatic Products, Collaborative Innovation Center of Seafood Deep Processing, National R&D Branch Center of Surimi and Surimi Products Processing, Jinzhou 121013, China;
2. Penglai Jinglu Fishery Co., Ltd., Yantai 265600, China;
3. Taixiang Group, Rongcheng Taixiang Food Products Co., Ltd., Ministry of Agriculture Key Laboratory of Frozen Prepared Marine Foods Processing, Weihai 264309, China;
4. Zhejiang Industrial Group Co., Ltd., Zhoushan 316100, China

摘要

摘要: 本论文以未漂洗金线鱼鱼糜为研究对象，分析了不同压力、保压时间对金线鱼鱼糜凝胶强度、TPA、持水性、蒸煮损失、白度、pH及微观结构的影响。结果表明，凝胶强度随压力增加而增加，随保压时间的增加呈现先增加后降低的趋势，300 MPa时达到最大值1150.71 g·mm，20 min时达到最大值1355.17 g·mm。经过超高压处理的鱼糜凝胶硬度均高于热处理的鱼糜凝胶硬度，在300 MPa和20 min时达到最大值。持水性随压力增大先增加后降低，在300 MPa时达到最大值72.72%，30 min时达到70.23%，继续处理变化不明显。蒸煮损失率随压力增大先降低后增加，300 MPa时达到最小值17.88%。随着压力的升高，凝胶的白度值逐渐增加，500 MPa时最高，相比200 MPa增加14.29%；随着保压时间的增长，白度值逐渐增加，在60 min时达到最大。在300 MPa和20 min时鱼肠内部网格结构最为致密，孔隙均匀。
- 金线鱼 /
- 未漂洗鱼糜 /
- 凝胶强度 /
- 超高压 /
- 保压时间
Abstract: In this paper,the effect of different pressure and dwell time on the gel strength,TPA,water holding capacity,cooking loss,whiteness,pH and microstructure of Nemipterus virgatus surimi were studied. The results showed that the gel strength increased with the increase of pressure and increased first and then decreased with the increase of dwell time,and reached the maximum value of 1150.71 g·mm at 300 MPa and reached the maximum value of 1355.17 g·mm at 20 min. The hardness of surimi gel treated by ultrahigh pressure was higher than that of heat treated surimi gel,and reached the maximum at 300 MPa and 20 min. The water holding capacity first increased and then decreased with the increase of pressure,reached the maximum value of 72.72% at 300 MPa,and 70.23% at 30 min. The continuous treatment did not change significantly. The cooking loss rate first decreased and then increased with the increase of pressure,reaching the minimum value of 17.88% at 300 MPa. With the increase of pressure,the whiteness of gel increased gradually,and reached the maximum value at 500 MPa,which increased by 14.29% compared with 200 MPa. With the increase of dwell time,the whiteness value increased gradually and reached the maximum at 60 min. At 300 MPa and 20 min,the mesh structure of fish sausage was the most compact and the pores were uniform.
- Nemipterus virgatus /
- unwashed surimi /
- gel strength /
- ultrahigh pressure /
- dwell time

HTML全文

参考文献(33)

[1]	任宏伟,胡柳. 我国鱼糜制品现状及发展态势[J]. 中国水产,2010(8):30-31.
[2]	农业部渔业局. 中国渔业年鉴[M]. 北京:中国农业出版社,2019.
[3]	刘军. 罗非鱼鱼糜及其复合鱼糜加工工艺的研究[D]. 南宁:广西大学,2013.
[4]	汪之和,陶妍,刘振华. 白鲢漂洗鱼糜和未漂洗碎鱼肉营养成分的分析比较[J]. 淡水渔业,1999,29(8):16-17.
[5]	Tadpitchayangkoon P,Park J W,Yongsawatdigul J. Gelation characteristics of tropical surimi under water bath and ohmic heating[J]. LWT-Food Science and Technology,2012,46(1):97-103.
[6]	Xiong G Q,Cheng W,Ye L X,et al. Effects of konjac glucomannan on physicochemical properties of myofibrillar protein and surimi gels from grass carp(Ctenopharyngodon idella)[J]. Food Chemistry,2009,116(2):413-418.
[7]	Rawdkuen S,Benjakul S. Whey protein concentrate:Autolysis inhibition and effects on the gel properties of surimi prepared from tropical fish[J]. Food Chemistry,2008,106(3):1077-1084.
[8]	Luo Y K,Shen H X,Pan D D,et al. Gel properties of surimi from silver carp(Hypophthalmichthys molitrix)as affected by heat treatment and soy protein isolate[J]. Food Hydrocolloids,2008,22(8):1513-1519.
[9]	Kadwudom P,Benjakul S,Kijroongrojana K. Properties of surimi gel as influenced by fish gelatin and microbial transglutaminase[J]. Food Bioscience,2013,1(3):39-47.
[10]	Trespalacios P,Pla R. Simultaneous application of transglutaminase and high pressure to improve functional properties of chicken meat gels[J]. Food Chemistry,2007,100(1):264-272.
[11]	Lanier T C,Hark K,Martin R E. A manual of standard methods for measuring and specifying the properties of surimi[M].Washington,DC:National Fisheries Institute,1991.
[12]	Apichartsrangkoon A,Lenward D A,Bell A E,et al. Physicochemical properties of high pressure treated wheat gluten[J]. Food Chemistry,1998,63(2):215-220.
[13]	Ma F,Chen C G,Zheng L,et al. Effect of high pressure processing on the gel properties of salt-soluble meat protein containing CaCl₂ and κ-carrageenan[J]. Meat Science,2013,95(1):22-26.
[14]	Osman Erkme. High hydrostatic pressureinactivation kinetics of Salmonella typhimurium[J]. High Pressure Research,2009,29(1):129-140.
[15]	仪淑敏,马兴胜,励建荣,等. 超高压对金线鱼鱼肉肠凝胶特性的影响[J]. 食品工业科技,2014,35(10):129-133.
[16]	Chaijan M,Panpipat W,Bennjakul S. Physicochemical properties and gel-forming ability of surimi from three species of mackerel caught in Southern Thailand[J]. Food Chemistry,2010,121(1):85-92.
[17]	Yang Z,Wang W,Wang H,et al. Effects of a highly resistant rice starch and pre-incubation temperatures on the physicochemical properties of surimi gel from grass carp(Ctenopharynodon idellus)[J]. Food Chemistry,2014,145:212-219.
[18]	Cao H,Fan D,Jiao X,et al. Heating surimi products using microwave combined with steam methods:Study on energy saving and quality[J]. Innovative Food Science & Emerging Technologies,2018,47:231-240.
[19]	Debusca A,Tahergorabi R,Beamer S K,et al. Interactions of dietary fiber and omega-3-rich oil with protein in surimi gels developed with salt substitute[J]. Food Chemistry,2013,141(1):201-208.
[20]	GB 5009.237-2016食品安全国家标准食品pH的测定[S]. 北京:中华人民共和国卫生部,2016.
[21]	王素雅,赵甲慧,鞠兴荣,等. 发芽对大豆蛋白凝胶性质的影响[J]. 食品与发酵工业,2011,37(10):62-66.
[22]	尚永彪,夏杨毅,李洪军. 转谷氨酰胺酶对猪肉肌原纤维蛋白凝胶性质的影响[J]. 食品科学,2009,30(21):135-139.
[23]	Nagano T,Tokita M. Viscoelastic properties and microstructures of 11S globulin and soybean protein isolate gels:Magnesium chloride-induced gels[J]. Food Hydrocolloids,2011,25(7):1647-1654.
[24]	Benjakul S,Visessanguan W,Chantarasuwan C. Effect of porcine plasma protein and setting on gel properties of surimi produced from fish caught in Thailand[J]. LWT-Food Science and Technology,2004,37(2):177-185.
[25]	Oh H,Pinder D N,Hemar Y,et al. Effect of high-pressure treatment on various starch-in-water suspensions[J]. Food Hydrocolloids,2008,22(1):150-155.
[26]	仪淑敏,马兴胜,励建荣,等. 超高压诱导鱼糜凝胶形成中水分特性及凝胶强度的相关性研究[J]. 中国食品学报,2015,15(7):26-31.
[27]	Verbeken D,Neirinck N,Meeren P V D,et al. Influence of κ-carrageenan on the thermal gelation of salt-soluble meat proteins[J]. Meat Science,2005,70(1):161-166.
[28]	Bajvic B,Bolumar T,Heinz V,et al. Quality considerations with high pressure processing of fresh and value added meatproducts[J]. Meat Science,2012,92(3):280-289.
[29]	Cheah P B,Ledward D A. Inhibition of metmyoglobin formation in fresh beef by pressure treatment[J]. Meat Science,1997,45(3):411-8.
[30]	Sikes A L,Tobin A B,Tume R K. Use of high pressure toreduce cook loss and improve texture of low-salt beef sausage batters[J]. Innovative Food Science & Emerging Technologies,2009,10(4):405-412.
[31]	Alberto Grossi,Jakob Søltoft-Jensen,Jes Christian Knudsen,et al. Synergistic cooperation of high pressure and carrot dietary fibre on texture and colour of pork sausages[J]. Meat Science,2011,89(2):195-201.
[32]	Juan C Ramirez-Suarez,Michael T Morrissey. Effect of high pressure processing(HPP)on shelf life of albacore tuna(Thunnus alalunga)minced muscle[J]. Innovative Food Science & Emerging Technologies,2006,7(1-2):19-27.
[33]	张兴,杨玉玲,马云,等. pH对肌原纤维蛋白及其热诱导凝胶非共价键作用力与结构的影响[J]. 中国农业科学,2017(3):564-573.

施引文献(9)

期刊类型引用(4)

1.	舒明，潘凡达，边腾飞，袁凯龙，项波卡，张勇刚，杨洋，钟卫鸿. 造纸法再造烟叶浓缩液中抗逆酵母的分离鉴定与代谢活性研究. 轻工学报. 2023(01): 54-62 . 百度学术
2.	张蓝月，孙万成，罗毅皓. 基于非靶向代谢组学分析不同地区羊肉代谢物的差异. 现代食品科技. 2023(07): 91-101 . 百度学术
3.	赵电波，马燕青，王少丹，王雯雯. 基于非靶向代谢组学解析肉桂精油纳米乳抑制假单胞菌CM2作用机制研究. 食品工业科技. 2023(17): 168-175 . 本站查看
4.	玉霞，赵飞燕，孙志宏. 肠道中有益菌培养组学的研究进展. 食品科学. 2023(23): 365-371 . 百度学术