• EI
  • Scopus
  • 食品科学与工程领域高质量科技期刊分级目录第一方阵T1
  • DOAJ
  • EBSCO
  • 北大核心期刊
  • 中国核心学术期刊RCCSE
  • JST China
  • FSTA
  • 中国精品科技期刊
  • 中国农业核心期刊
  • CA
  • WJCI
  • 中国科技核心期刊CSTPCD
  • 中国生物医学SinoMed
中国精品科技期刊2020
溶剂法提取火龙果籽油工艺优化及其理化性质[J]. 食品工业科技, 2013, (15): 184-189. DOI: 10.13386/j.issn1002-0306.2013.15.020
引用本文: 溶剂法提取火龙果籽油工艺优化及其理化性质[J]. 食品工业科技, 2013, (15): 184-189. DOI: 10.13386/j.issn1002-0306.2013.15.020
Optimization of extraction with the solvent method and physicochemical properties of pitaya seed oil[J]. Science and Technology of Food Industry, 2013, (15): 184-189. DOI: 10.13386/j.issn1002-0306.2013.15.020
Citation: Optimization of extraction with the solvent method and physicochemical properties of pitaya seed oil[J]. Science and Technology of Food Industry, 2013, (15): 184-189. DOI: 10.13386/j.issn1002-0306.2013.15.020

溶剂法提取火龙果籽油工艺优化及其理化性质

Optimization of extraction with the solvent method and physicochemical properties of pitaya seed oil

  • 摘要: 以火龙果籽(H.polyrhizus)为原料,采用索氏抽提法提取火龙果籽油,通过单因素实验研究了抽提溶剂、干燥时间、液料比、抽提温度、抽提时间等因素对油脂提取率的影响,响应面优化实验确定了溶剂抽提火龙果籽油的最佳工艺条件,并分析了火龙果籽油的理化性质及其脂肪酸组成。结果表明,石油醚抽提法提取火龙果籽油的最佳条件为:液料比7∶1(mL∶g),抽提温度78℃,抽提时间3h,在此条件下油脂提取率31.47%;火龙果籽油的酸值、过氧化值等指标达到食用油脂的国家标准;GC-MS分析结果表明火龙果籽油中含8种脂肪酸,主要为亚油酸(47.98%)、油酸(28.13%)、棕榈酸(16.77%)、硬脂酸(5.02%);通过面积归一化法计算可知其不饱和脂肪酸占油脂总量的77.58%,因而是一种具有较高的开发潜力的营养油脂。 

     

    Abstract: The Soxhlet extraction method was utilized to extract the oil from pitaya seed ( H.polyrhizus) .Single-factor tests were applied to study the effects of extraction solvent, drying time, solvent /material ratio, extraction temperature and time on the yield of pitaya seed oil.Then, response surface methodology ( RSM) was conducted to ascertain the optimum conditions for oil extraction. The physicochemical properties and fatty acid composition of the oil were analyzed. Results indicated that the optimal parameters of extraction were using petroleum ether as solvent, solvent /material ratio 7 ∶ 1 ( mL∶ g ) , extraction temperature 78℃, and time 3h. Under these conditions, the extraction yield was high up 31.47% ( v /w) .The acid value and peroxide value of the produced pitaya seed oil met a criterion for edible oils of nation. According to the results of the GC - MS analysis, the pitaya seed oil was composed of eight kinds of fatty acids.The contents of linoleic acid, oleic acid, palmitic acid and stearic acid were 47.98% , 28.13% , 16.77% and 5.02% , respectively. Calculating via the area normalization method, the unsaturated fatty acid accounted for 77.58% ( w /w) of the total amount of oil. Therefore, the pitaya seed oil was a kind of nutritional oil with a high development potential.

     

/

返回文章
返回